Hostname: page-component-669899f699-b58lm Total loading time: 0 Render date: 2025-05-03T01:56:55.177Z Has data issue: false hasContentIssue false
  • English
  • Français

Excitation and stability of nonlinear compressible Görtler vortices and streaks induced by free-stream vortical disturbances

Published online by Cambridge University Press:  04 December 2024

Dongdong Xu Open the ORCID record for Dongdong Xu [Opens in a new window] ,
Pierre Ricco Open the ORCID record for Pierre Ricco [Opens in a new window]  and
Elena Marensi Open the ORCID record for Elena Marensi [Opens in a new window]
Dongdong Xu
Affiliation:
School of Mechanical, Aerospace and Civil Engineering, The University of Sheffield, Sheffield S1 3JD, UK
Pierre Ricco*
Affiliation:
School of Mechanical, Aerospace and Civil Engineering, The University of Sheffield, Sheffield S1 3JD, UK
Elena Marensi
Affiliation:
School of Mechanical, Aerospace and Civil Engineering, The University of Sheffield, Sheffield S1 3JD, UK
*
†Email address for correspondence: [email protected]
Get access Rights & Permissions [Opens in a new window]

Abstract

We study the generation, nonlinear development and secondary instability of unsteady Görtler vortices and streaks in compressible boundary layers exposed to free-stream vortical disturbances and evolving over concave, flat and convex walls. The formation and evolution of the disturbances are governed by the compressible nonlinear boundary-region equations, supplemented by initial and boundary conditions that characterise the impact of the free-stream disturbances on the boundary layer. Computations are performed for parameters typical of flows over high-pressure turbine blades, where the Görtler number, a measure of the curvature effects, and the disturbance Reynolds number, a measure of the nonlinear effects, are order-one quantities. At moderate intensities of the free-stream disturbances, increasing the Görtler number renders the boundary layer more unstable, while increasing the Mach number or the frequency stabilises the flow. As the free-stream disturbances become more intense, vortices over concave surfaces no longer develop into the characteristic mushroom-shaped structures, while the flow over convex surfaces is destabilised. An occurrence map identifies Görtler vortices or streaks for different levels of free-stream disturbances and Görtler numbers. Our calculations capture well the experimental measurements of the enhanced skin friction and wall-heat transfer over turbine-blade pressure surfaces. The time-averaged wall-heat transfer modulations, termed hot fingers, are elongated in the streamwise direction and their spanwise wavelength is half of the characteristic wavelength of the free-stream disturbances. Nonlinearly saturated disturbances are unstable to secondary high-frequency modes, whose growth rate increases with the Görtler number. A new varicose even mode is reported, which may promote transition to turbulence at the stem of nonlinear streaks.

JFM classification

Aerodynamics: High-speed flow Boundary Layers: Boundary layer receptivity Instability: Transition to turbulence
Type
JFM Papers
Information
Journal of Fluid Mechanics , Volume 1000 , 10 December 2024 , A93
Check for updates
Copyright
© The Author(s), 2024. Published by Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

Article purchase

Temporarily unavailable

References

Anderson, J.D. 2000 Hypersonic and High Temperature Gas Dynamics, 2nd edn. AIAA-Education Series.Google Scholar
Arts, T., Lambertderouvroit, M. & Rutherford, A.W. 1990 Aero-thermal investigation of a highly loaded transonic linear turbine guide vane cascade. A test case for inviscid and viscous flow computations. Technical Note 174. van Kármán Institute.CrossRefGoogle Scholar
Baughn, J.W., Butler, R.J., Byerley, A.R. & Rivir, R.B. 1995 An experimental investigation of heat transfer, transition and separation on turbine blades at low Reynolds number and high turbulence intensity. ASME Paper 95-WA/HT-25.Google Scholar
Beckwith, I.E., Harvey, W.D., Harris, J.E. & Holley, B.B. 1973 Control of supersonic wind-tunnel noise by laminarization of nozzle-wall boundary layers. NASA TM X-2879. NASA Langley Research Center.Google Scholar
Bhaskaran, R. & Lele, S.K. 2010 Large eddy simulation of free-stream turbulence effects on heat transfer to a high-pressure turbine cascade. J. Turbul. 11, N6.CrossRefGoogle Scholar
Bogolepov, V.V. 2001 Asymptotic analysis of the structure of long-wave Görtler vortices in a hypersonic boundary layer. J. Appl. Mech. Tech. Phys. 42 (5), 773–785.CrossRefGoogle Scholar
Bons, J. 2005 A critical assessment of Reynolds analogy for turbine flows. J. Heat Transfer 127 (5), 472–485.CrossRefGoogle Scholar
Butler, R.J., Byerley, A.R., VanTreuren, K. & Baughn, J.W. 2001 The effect of turbulence intensity and length scale on low-pressure turbine blade aerodynamics. Intl J. Heat Fluid Flow 22 (2), 123–133.CrossRefGoogle Scholar
Camci, C. & Arts, T. 1990 An experimental convective heat transfer investigation around a film-cooled gas turbine blade. Trans. ASME J. Turbomach. 112 (3), 497–503.CrossRefGoogle Scholar
Canuto, C., Hussaini, M.Y., Quarteroni, A. & Zang, T.A. 1988 Spectral Methods in Fluid Dynamics. Springer.CrossRefGoogle Scholar
Chilton, T.H. & Colburn, A.P. 1934 Mass transfer (absorption) coefficients prediction from data on heat transfer and fluid friction. Ind. Engng Chem. 26 (11), 1183–1187.CrossRefGoogle Scholar
Dando, A.H. & Seddougui, S.O. 1993 The compressible Görtler problem in two-dimensional boundary layers. IMA J. Appl. Maths 51 (1), 27–67.CrossRefGoogle Scholar
Ðurović, K., De Vincentiis, L., Simoni, D., Lengani, D., Pralits, J., Henningson, D.S. & Hanifi, A. 2021 Free-stream turbulence-induced boundary-layer transition in low-pressure turbines. Trans. ASME J. Turbomach. 143 (8), 081015.CrossRefGoogle Scholar
Feng, Z., Cai, C., Lee, C. & Yang, D. 2024 Investigation of an overlap of heating peaks in the hypersonic boundary layer over a blunt cone. Phys. Rev. Fluids 9 (7), L071901.CrossRefGoogle Scholar
Floryan, J.M. 1991 On the Görtler instability of boundary layers. Prog. Aerosp. Sci. 28 (3), 235–271.CrossRefGoogle Scholar
Fransson, J.H.M. & Shahinfar, S. 2020 On the effect of free-stream turbulence on boundary-layer transition. J. Fluid Mech. 899, A23.CrossRefGoogle Scholar
Fu, Y. & Hall, P. 1991 a Effects of Görtler vortices, wall cooling and gas dissociation on the Rayleigh instability in a hypersonic boundary layer. NASA Rep. 91-87.Google Scholar
Fu, Y. & Hall, P. 1991 b Nonlinear development and secondary instability of Görtler vortices in hypersonic flows. NASA Rep. 91-39.Google Scholar
Ghorbanian, K., Soltani, M.R. & Manshadi, M.D. 2011 Experimental investigation on turbulence intensity reduction in subsonic wind tunnels. Aerosp. Sci. Technol. 15 (2), 137–147.CrossRefGoogle Scholar
Gourdain, N., Gicquel, L.Y.M. & Collado, E. 2012 Comparison of RANS and LES for prediction of wall heat transfer in a highly loaded turbine guide vane. J. Propul. Power 28 (2), 423–433.CrossRefGoogle Scholar
Hall, P. 1982 Taylor–Görtler vortices in fully developed or boundary-layer flows: linear theory. J. Fluid Mech. 124, 475–494.CrossRefGoogle Scholar
Hall, P. 1983 The linear development of Görtler vortices in growing boundary layers. J. Fluid Mech. 130 (41), 243–266.CrossRefGoogle Scholar
Hall, P. 1990 Görtler vortices in growing boundary layers: the leading edge receptivity problem, linear growth and the nonlinear breakdown stage. Mathematika 37 (74), 151–189.CrossRefGoogle Scholar
Hall, P. & Fu, Y. 1989 On the Görtler vortex instability mechanism at hypersonic speeds. Theor. Comput. Fluid Dyn. 1 (3), 125–134.CrossRefGoogle Scholar
Hall, P. & Malik, M. 1989 The growth of Görtler vortices in compressible boundary layers. J. Engng Maths 23 (3), 239–251.CrossRefGoogle Scholar
Huang, G., Si, W. & Lee, C. 2021 Inner structures of Görtler streaks. Phys. Fluids 33 (3), 034116.CrossRefGoogle Scholar
Jiang, X.Y., Gu, D.W., Lee, C.B., Smith, C.R. & Linden, P.F. 2021 A metamorphosis of three-dimensional wave structure in transitional and turbulent boundary layers. J. Fluid Mech. 914, A4.CrossRefGoogle Scholar
Jiang, X.Y., Lee, C.B., Chen, X., Smith, C.R. & Linden, P.F. 2020 a Structure evolution at early stage of boundary-layer transition: simulation and experiment. J. Fluid Mech. 890, A11.CrossRefGoogle Scholar
Jiang, X.Y., Lee, C.B., Smith, C.R., Chen, J.W. & Linden, P.F. 2020 b Experimental study on low-speed streaks in a turbulent boundary layer at low Reynolds number. J. Fluid Mech. 903, A6.CrossRefGoogle Scholar
Kanani, Y., Acharya, S. & Ames, F. 2019 Large eddy simulation of the laminar heat transfer augmentation on the pressure side of a turbine vane under freestream turbulence. Trans. ASME J. Turbomach. 141 (4), 041004.CrossRefGoogle Scholar
Lee, C.B. & Wu, J.Z. 2008 Transition in wall-bounded flows. Appl. Mech. Rev. 61 (3), 030802.CrossRefGoogle Scholar
Leib, S.J., Wundrow, D.W. & Goldstein, M.E. 1999 Effect of free-stream turbulence and other vortical disturbances on a laminar boundary layer. J. Fluid Mech. 380, 169–203.CrossRefGoogle Scholar
Lengani, D., Simoni, D., Pralits, J.O., Ðurović, K., De Vincentiis, L., Henningson, D.S. & Hanifi, A. 2022 On the receptivity of low-pressure turbine blades to external disturbances. J. Fluid Mech. 937, A36.CrossRefGoogle Scholar
Marensi, E. & Ricco, P. 2017 Growth and wall-transpiration control of nonlinear unsteady Görtler vortices forced by free-stream vortical disturbances. Phys. Fluids 29 (11), 114106.CrossRefGoogle Scholar
Marensi, E., Ricco, P. & Wu, X. 2017 Nonlinear unsteady streaks engendered by the interaction of free-stream vorticity with a compressible boundary layer. J. Fluid Mech. 817, 80–121.CrossRefGoogle Scholar
Matsubara, M. & Alfredsson, P.H. 2001 Disturbance growth in boundary layers subjected to free-stream turbulence. J. Fluid Mech. 430, 149–168.CrossRefGoogle Scholar
Mayle, R.E. 1991 The 1991 IGTI scholar lecture: the role of laminar-turbulent transition in gas turbine engines. Trans. ASME J. Turbomach. 113, 509–537.CrossRefGoogle Scholar
Morata, E.C., Gourdain, N., Duchaine, F. & Gicquel, L.Y.M. 2012 Effects of free-stream turbulence on high pressure turbine blade heat transfer predicted by structured and unstructured LES. Intl J. Heat Mass Transfer 55 (21-22), 5754–5768.CrossRefGoogle Scholar
Nagarajan, S., Lele, S.K. & Ferziger, J.H. 2007 Leading-edge effects in bypass transition. J. Fluid Mech. 572, 471–504.CrossRefGoogle Scholar
Qin, F. & Wu, X. 2016 Response and receptivity of the hypersonic boundary layer past a wedge to free-stream acoustic, vortical and entropy disturbances. J. Fluid Mech. 797, 874–915.CrossRefGoogle Scholar
Radomsky, R.W. & Thole, K.A. 2002 Detailed boundary layer measurements on a turbine stator vane at elevated freestream turbulence levels. Trans. ASME J. Turbomach. 124 (1), 107–118.CrossRefGoogle Scholar
Ren, J. & Fu, S. 2014 Competition of the multiple Görtler modes in hypersonic boundary layer flows. Sci. China Phys. Mech. Astron. 57 (6), 1178–1193.CrossRefGoogle Scholar
Ren, J. & Fu, S. 2015 Secondary instabilities of Görtler vortices in high-speed boundary layer flows. J. Fluid Mech. 781, 388–421.CrossRefGoogle Scholar
Ricco, P. 2007 Response of a compressible laminar boundary layer to free-stream turbulent disturbances. PhD thesis, Imperial College London (University of London).CrossRefGoogle Scholar
Ricco, P., Luo, J. & Wu, X. 2011 Evolution and instability of unsteady nonlinear streaks generated by free-stream vortical disturbances. J. Fluid Mech. 677, 1–38.CrossRefGoogle Scholar
Ricco, P. & Wu, X. 2007 Response of a compressible laminar boundary layer to free-stream vortical disturbances. J. Fluid Mech. 587, 97–138.CrossRefGoogle Scholar
Roy, C.J. & Blottner, F.G. 2006 Review and assessment of turbulence models for hypersonic flows. Prog. Aerosp. Sci. 42 (7–8), 469–530.CrossRefGoogle Scholar
Saric, W.S. 1994 Görtler vortices. Annu. Rev. Fluid Mech. 26 (1), 379–409.CrossRefGoogle Scholar
Schneider, S.P. 1999 Flight data for boundary-layer transition at hypersonic and supersonic speeds. J. Spacecr. Rockets 36 (1), 8–20.CrossRefGoogle Scholar
Schneider, S.P. 2008 Development of hypersonic quiet tunnels. J. Spacecr. Rockets 45-4, 641–664.CrossRefGoogle Scholar
Schneider, S.P. 2015 Developing mechanism-based methods for estimating hypersonic boundary-layer transition in flight: the role of quiet tunnels. Prog. Aerosp. Sci. 72, 17–29.CrossRefGoogle Scholar
Schultz, M.P. & Volino, R.J. 2003 Effects of concave curvature on boundary layer transition under high freestream turbulence conditions. J. Fluids Engng 125 (1), 18–27.CrossRefGoogle Scholar
Sescu, A., Afsar, M. & Hattori, Y. 2020 Streaks in high-speed boundary layers: a view through the full nonlinear boundary-region equations. AIAA Paper 2020-0830.CrossRefGoogle Scholar
Song, R., Zhao, L. & Huang, Z. 2020 Secondary instability of stationary Görtler vortices originating from first/second Mack mode. Phys. Fluids 32, 034109.CrossRefGoogle Scholar
Stewartson, K. 1964 The Theory of Laminar Boundary Layers in Compressible Fluids. Clarendon Press.CrossRefGoogle Scholar
Sun, Y. & Smith, H. 2017 Review and prospect of supersonic business jet design. Prog. Aerosp. Sci. 90, 12–38.CrossRefGoogle Scholar
Varty, J.W. & Ames, F.E. 2016 Experimental heat transfer distributions over an aft loaded vane with a large leading edge at very high turbulence levels. ASME Paper IMECE2016-67029.CrossRefGoogle Scholar
Viaro, S. & Ricco, P. 2018 Neutral stability curves of low-frequency Görtler flow generated by free-stream vortical disturbances. J. Fluid Mech. 845, R1.CrossRefGoogle Scholar
Viaro, S. & Ricco, P. 2019 a Compressible unsteady Görtler vortices subject to free-stream vortical disturbances. J. Fluid Mech. 867, 250–299.CrossRefGoogle Scholar
Viaro, S. & Ricco, P. 2019 b Neutral stability curves of compressible Görtler flow generated by low-frequency free-stream vortical disturbances. J. Fluid Mech. 876, 1146–1157.CrossRefGoogle Scholar
Wheeler, A.P.S., Sandberg, R.D., Sandham, N.D., Pichler, R., Michelassi, V. & Laskowski, G. 2016 Direct numerical simulations of a high-pressure turbine vane. Trans. ASME J. Turbomach. 138 (7), 071003.CrossRefGoogle Scholar
Wright, L.M., Malak, M.F., Crites, D.C., Morris, M.C., Yelavkar, V. & Bilwani, R. 2014 Review of platform cooling technology for high pressure turbine blades. ASME Paper GT2014-26373.CrossRefGoogle Scholar
Wu, X. & Choudhari, M. 2003 Linear and nonlinear instabilities of a blasius boundary layer perturbed by streamwise vortices. Part 2. Intermittent instability induced by long-wavelength Klebanoff modes. J. Fluid Mech. 483, 249–286.CrossRefGoogle Scholar
Wu, X., Zhao, D. & Luo, J. 2011 Excitation of steady and unsteady Görtler vortices by free-stream vortical disturbances. J. Fluid Mech. 682, 66–100.CrossRefGoogle Scholar
Xu, D., Liu, J. & Wu, X. 2020 Görtler vortices and streaks in boundary layer subject to pressure gradient: excitation by free stream vortical disturbances, nonlinear evolution and secondary instability. J. Fluid Mech. 900, A15.CrossRefGoogle Scholar
Xu, D., Ricco, P. & Duan, L. 2024 Görtler instability and transition in compressible flows. AIAA J. 62 (2), 489–517.CrossRefGoogle Scholar
Xu, D., Zhang, Y. & Wu, X. 2017 Nonlinear evolution and secondary instability of steady and unsteady Görtler vortices induced by free-stream vortical disturbances. J. Fluid Mech. 829, 681–730.CrossRefGoogle Scholar
Zhang, Y., Zaki, T., Sherwin, S. & Wu, X. 2011 Nonlinear response of a laminar boundary layer to isotropic and spanwise localized free-stream turbulence. AIAA Paper 2011-3292.CrossRefGoogle Scholar
Zhao, Y. & Sandberg, R.D. 2020 Bypass transition in boundary layers subject to strong pressure gradient and curvature effects. J. Fluid Mech. 888, A4.CrossRefGoogle Scholar